LOADER XX‐XX Codes
Bobcat Controller
Code
01-16
01-17
02-16
02-17
03-09
03-10
03-11
03-14
03-22
04-09
04-14
04-15
04-21
04-22
05-09
05-10
05-11
05-14
05-15
05-21
05-22
06-10
06-11
06-13
06-15
06-18
07-10
07-11
07-15
07-21
07-22
08-10
08-11
08-15
08-21
08-22
09-09
09-21
09-22
10-16
10-17
11-05
11-06
12-21
12-22
12-23
13-05
13-06
13-07
14-02
14-03
15-02
15-03
16-05
16-06
16-07
17-05
17-06
17-07
18-05
18-06
18-07
19-02
19-03
20-02
20-03
21-02
21-03
22-02
22-03
23-02
23-03
24-02
Description
Air Filter Not Connected
Air Filter Plugged
Hydraulic Implement Filter Not Connected
Hydraulic Implement Filter Plugged
Battery Voltage Low
Battery Voltage High
Battery Voltage Extremely High
Battery Voltage Extremely Low
Battery Voltage Out of Range Low
Engine Oil Pressure Low
Engine Oil Pressure Extremely Low
Engine Oil Pressure In Shutdown
Engine Oil Pressure Out Of Range High
Engine Oil Pressure Out Of Range Low
Hydraulic Charge Pressure Low
Hydraulic Charge Pressure High
Hydraulic Charge Pressure Extremely High
Hydraulic Charge Pressure Extremely Low
Hydraulic Charge Pressure In Shutdown
Hydraulic Charge Pressure Out Of Range High
Hydraulic Charge Pressure Out Of Range Low
Engine Speed High
Engine Speed Extremely High
Engine Speed No Signal
Engine Speed In Shutdown
Engine Speed Out Of Range
Hydraulic Oil Temperature High
Hydraulic Oil Temperature Extremely High
Hydraulic Oil Temperature In Shutdown
Hydraulic Oil Temperature Out Of Range High
Hydraulic Oil Temperature Out Of Range Low
Engine Coolant Temperature High
Engine Coolant Temperature Extremely High
Engine Coolant Temperature In Shutdown
Engine Coolant Temperature Out Of Range High
Engine Coolant Temp Out Of Range Low
Fuel Level Low
Fuel Level Out Of Range High
Fuel Level Out Of Range Low
Hydraulic Charge Filter Not Connected
Hydraulic Charge Filter Plugged
Seat Bar Sensor Short To Battery
Seat Bar Sensor Short To Ground
Front Auxiliary Thumb Paddle Switch Out Of Range High
Front Auxiliary Thumb Paddle Switch Out Of Range Low
Front Auxiliary PWM Switch Not In Neutral
Fuel Shutoff Hold Coil Short To Battery
Fuel Shutoff Hold Solenoid Short To Ground
Fuel Shutoff Hold Solenoid Open Circuit
Fuel Shutoff Pull Coil Error On
Fuel Shutoff Pull Coil Error Off
Traction Lock Pull Coil Error On
Traction Lock Pull Coil Error Off
Traction Lock Hold Coil Short To Battery
Traction Lock Hold Coil Short To Ground
Traction Lock Hold Solenoid Open Circuit
Hydraulic Lock Solenoid Short To Battery
Hydraulic Lock Solenoid Short To Ground
Hydraulic Lock Solenoid Open Circuit
Spool Lock Coil Short To Battery
Spool Lock Coil Short To Ground
Spool Lock Coil Open Circuit
Bucket Position Solenoid Error On
Bucket Position Solenoid Error Off
Two Speed Solenoid Error On
Two Speed Solenoid Error Off
Glow Plug Error On
Glow Plug Error Off
Starter Error On
Starter Error Off
Rear Base Solenoid Error On
Rear Base Solenoid Error Off
Rear Rod Solenoid Error On
Bobcat Controller (Cont'd)
Code
24-03
25-02
25-03
26-02
26-03
27-02
27-03
28-02
28-03
29-02
29-03
30-28
31-28
33-23
34-04
35-02
35-03
36-48
37-02
37-03
37-07
39-04
39-12
39-13
39-16
39-28
39-48
40-04
40-12
40-13
40-16
40-28
40-48
41-09
41-10
41-11
44-02
44-03
45-02
45-03
46-02
46-03
47-21
47-22
48-02
48-03
49-02
49-03
60-21
60-22
60-23
64-02
64-03
74-72
76-73
77-48
78-74
80-02
80-03
81-02
81-03
82-02
82-03
83-02
83-03
84-02
84-03
85-02
85-03
86-02
86-03
87-02
87-03
Description
Rear Rod Solenoid Error Off
Rear Auxiliary Relief Solenoid Error On
Rear Auxiliary Relief Solenoid Error Off
Front Base Solenoid Error On
Front Base Solenoid Error Off
Front Rod Solenoid Error On
Front Rod Solenoid Error Off
Diverter Solenoid Error On
Diverter Solenoid Error Off
High Flow Solenoid Error On
High Flow Solenoid Error Off
Controller Memory Failure
Interrupted Power
Bobcat Controller Not Programmed
Deluxe Panel In Error
Hydraulic Fan Error On
Hydraulic Fan Error Off
Multiple ACDs Present
Two Speed Make-up Solenoid Error On
Two Speed Make-up Error Off
Two Speed Secondary Solenoid Open Circuit
Left Joystick Switches In Error
Left CAN Joystick Thumb Paddle Switch Not In Neutral
Left CAN Joystick Grip No Communication
Left CAN Joystick Base No Communication
Left CAN Joystick Internal Failure
Left CAN Joystick Multiple
Right Joystick Switches In Error
Right CAN Joystick Thumb Paddle Switch Not In Neutral
Right CAN Joystick Grip No Communication
Right CAN Joystick Base No Communication
Right CAN Joystick Internal Failure
Right CAN Joystick Multiple
Alternator Low Output
Alternator Voltage High
Alternator Voltage Extremely High
Horn Relay Error On
Horn Relay Error Off
Right Blinker Relay Error On
Right Blinker Relay Error Off
Left Blinker Relay Error On
Left Blinker Relay Error Off
8 Volt Sensor Supply Out Of Range High
8 Volt Sensor Supply Out Of Range Low
Front Light Relay Error On
Front Light Relay Error Off
Rear Light Relay Error On
Rear Light Relay Error Off
Rear Auxiliary Control Out Of Range High
Rear Auxiliary Control Out Of Range Low
Rear Auxiliary Control Not In Neutral
Switched Power Relay Error On
Switched Power Relay Error Off
Main Bobcat Controller In Boot Code
Left Display Panel System Rx In Error
Key Switch Multiple
Door / Transport Lock Open / Active
ACD/RACD Output "A" Error On
ACD/RACD Output "A" Error Off
ACD/RACD Output "B" Error On
ACD/RACD Output "B" Error Off
ACD/RACD Output "C" Error On
ACD/RACD Output "C" Error Off
ACD/RACD Output "D" Error On
ACD/RACD Output "D" Error Off
ACD/RACD Output "E" Error On
ACD/RACD Output "E" Error Off
ACD/RACD Output "F" Error On
ACD/RACD Output "F" Error Off
ACD/RACD Output "G" Error On
ACD/RACD Output "G" Error Off
ACD/RACD Output "H" Error On
ACD/RACD Output "H" Error Off
Update June 2009
LOADER XX‐XX Codes
ACS Controller
Code
32-04
32-23
32-24
32-25
32-31
32-32
32-33
32-34
32-35
32-36
32-37
32-38
32-39
32-40
32-41
32-49
32-50
32-51
32-52
32-53
32-54
32-55
32-56
32-57
32-58
32-59
32-60
32-61
32-62
32-63
32-64
32-65
32-66
32-67
32-68
32-70
32-71
32-75
32-76
32-97
40-05
40-07
Description
No Communication From ACS Controller
ACS Controller Not Calibrated
ACS Controller Calibration Performed
ACS Controller Calibration Failure
ACS / AHC Tilt Actuator Fault
AHC Tilt Actuator Wiring Fault
AHC Tilt Handle Wiring Fault
ACS / AHC Tilt Actuator Not In Neutral
ACS / AHC Tilt Handle / Pedal Not In Neutral, SJC Right Joystick X-axis Not In Neutral
ACS / AHC Lift Actuator Fault
AHC Lift Actuator Wiring Fault
AHC Lift Handle Wiring Fault
ACS / AHC Lift Actuator Not In Neutral
ACS / AHC Lift Handle / Pedal Not In Neutral, SJC Right Joystick Y-axis Not In Neutral
AHC Controller No Communication
ACS Lift Actuator Short To Ground (Error Off)
ACS Tilt Actuator Short To Ground (Error Off)
ACS Lift Actuator Short To Battery (Error On)
ACS Tilt Actuator Short To Battery (Error On)
ACS Lift Handle / Pedal Short To Ground, SJC Right Joystick Y-axis Short To Ground
ACS Tilt Handle / Pedal Short To Ground, SJC Right Joystick X-axis Short To Ground
ACS Lift Handle / Pedal Short To Battery, SJC Right Joystick Y-axis Short To Battery
ACS Tilt Handle Pedal Short To Battery, SJC Right Joystick X-axis Short To Battery
ACS Lift Actuator Reduced Performance
ACS Tilt Actuator Reduced Performance
ACS Lift Actuator Wrong Direction
ACS Tilt Actuator Wrong Direction
ACS Handle Lock Short To Ground
ACS Handle Lock Short To Battery
ACS Pedal Lock Short To Ground
ACS Pedal Lock Short To Battery
ACS Sensor Supply Voltage Out Of Range
ACS Battery Voltage Out Of Range
ACS Operating Mode Switch Flipped While Operating
ACS Lift Handle Information Error
Right Joystick Y-axis Out Of Range Low
Right Joystick Y-axis Out Of Range High
Interrupted Un-switched Power
CAN Joystick Information Error
ACS Controller Programmed
Right CAN Joystick X-axis Not In Neutral
Right CAN Joystick Y-axis Not In Neutral
AWS-SJC Controller
Code
38-01
38-02
38-03
38-04
38-05
38-06
38-07
38-08
38-09
38-10
38-11
38-12
38-13
38-14
38-15
38-16
38-17
38-18
38-19
38-20
38-21
38-22
38-23
38-24
38-25
Description
CAN Joystick Information Error
Remote Control Information Error
Actuator Calibration Failure
AWS/SJC Controller No Communication
Left Analog Joystick X-Axis Not In Neutral
Right Analog Joystick X-Axis Not In Neutral
Left Analog Joystick Y-Axis Not In Neutral
Right Joystick Y-Axis Not In Neutral
Operating Mode Switch Short to Ground or Battery
Actuator Calibration Performed
AWS / SJC Lift Actuator Not In Neutral
AWS / SJC Tilt Actuator Not In Neutral
AWS / SJC Lift Actuator Fault
AWS / SJC Tilt Actuator Fault
AWS / SJC Right Wheel Speed Fault
AWS / SJC Left Wheel Speed Fault
AWS / SJC Tilt Actuator Reduced Performance
AWS / SJC Lift Actuator Reduced Performance
Left Joystick X-Axis Out Of Range High
Right Joystick X-Axis Out Of Range High
Left Joystick Y-Axis Out Of Range High
Right Joystick Y-Axis Out Of Range High
Right Front Steering Sensor Out Of Range High
Left Front Steering Sensor Out Of Range High
Right Rear Steering Sensor Out Of Range High
AWS-SJC Controller (Cont'd)
Code
38-26
38-27
38-28
38-29
38-30
38-31
38-32
38-33
38-34
38-35
38-36
38-37
38-38
38-39
38-40
38-41
38-42
38-43
38-44
38-45
38-46
38-47
38-48
38-49
38-50
38-51
38-52
38-53
38-54
38-55
38-56
38-57
38-58
38-59
38-60
38-61
38-62
38-63
38-64
38-65
38-66
38-67
38-68
38-69
38-70
38-71
38-72
38-73
38-74
38-75
38-85
38-86
38-87
38-88
38-89
38-90
38-93
38-94
38-95
38-96
38-97
38-98
38-99
39-05
39-07
40-05
40-07
Description
Left Rear Steering Sensor Out Of Range High
AWS / SJC Lift Actuator Out Of Range High
AWS / SJC Tilt Actuator Out Of Range High
Left Joystick X-Axis Out Of Range Low
Right Joystick X-axis Out Of Range Low
Left Joystick Y-Axis Out Of Range Low
Right Joystick Y-Axis Out Of Range Low
Right Front Steering Sensor Out Of Range Low
Left Front Steering Sensor Out Of Range Low
Right Rear Steering Sensor Out Of Range Low
Left Rear Steering Sensor Out Of Range Low
5 Volt Sensor Supply 1 Out Of Range Low
5 Volt Sensor Supply 2 Out Of Range Low
AWS / SJC Lift Actuator Short To Ground
AWS / SJC Tilt Actuator Short To Ground
Tilt Actuator Wrong Direction
Lift Actuator Wrong Direction
Left Forward Drive Solenoid Error On
Left Reverse Drive Solenoid Error On
Right Forward Drive Solenoid Error On
Right Reverse Drive Solenoid Error On
Right Front Steering Solenoid Error On
Left Front Steering Solenoid Error On
Right Rear Steering Solenoid Error On
Left Rear Steering Solenoid Error On
Pressure Control Steering Solenoid Error On
Backup Alarm Error On
Left Forward Drive Solenoid Error Off
Left Reverse Drive Solenoid Error Off
Right Forward Drive Solenoid Error Off
Right Reverse Drive Solenoid Error Off
Right Front Extend Steering Solenoid Error Off
Right Front Retract Steering Solenoid Error Off
Left Front Extend Steering Solenoid Error Off
Left Front Retract Steering Solenoid Error Off
Right Rear Extend Steering Solenoid Error Off
Right Rear Retract Steering Solenoid Error Off
Left Rear Extend Steering Solenoid Error Off
Left Rear Retract Steering Solenoid Error Off
Pressure Control Steering Solenoid Error Off
Backup Alarm Short To Ground
No Communication From Bobcat Controller
Wheel Angle Sensors Not Calibrated
AWS / SJC Controller Not Calibrated
Interrupted Power
Battery Voltage Out Of Range
Drive Pump Not Calibrated
Operating Mode Switch Pressed While Operating
Right Wheel Speed Uncommanded Motion
Left Wheel Speed Uncommanded Motion
5.0 Volt Sensor Supply 1 Out Of Range High
Sensor Supply 2 Out Of Range High
Right Front Steering Solenoid Error
Left Front Steering Solenoid Error
Right Rear Steering Solenoid Error
Left Rear Steering Solenoid Error
Right Speed Sensor Unresponsive
Left Speed Sensor Unresponsive
Left Speed Sensor Reverse Direction
Right Speed Sensor Reverse Direction
AWS/SJC Controller Programmed
Controller In Drive Calibration Mode
AWS Controller In Wheel Position Calibration Mode
Left CAN Joystick X-axis Not In Neutral
Left CAN Joystick Y-axis Not In Neutral
Right CAN Joystick X-axis Not In Neutral
Right CAN Joystick Y-axis Not In Neutral
Update June 2009
LOADER XX‐XX Codes
SSL Drive / Drive Plus Controller
Code
39-05
39-07
75-01
75-04
75-05
75-07
75-08
75-09
75-13
75-14
75-15
75-16
75-17
75-18
75-19
75-21
75-23
75-24
75-25
75-26
75-27
75-28
75-29
75-31
75-33
75-34
75-35
75-36
75-37
75-38
75-39
75-40
75-41
75-42
75-43
75-44
75-45
75-46
75-47
75-48
75-49
75-50
75-51
75-52
75-53
75-54
75-55
75-56
75-57
75-58
75-59
75-60
75-61
75-62
75-63
75-64
75-65
75-66
75-67
75-68
75-69
75-70
75-71
75-72
75-73
75-74
75-75
75-76
75-77
75-78
75-79
75-80
75-81
Description
Left CAN Joystick X-axis Not In Neutral
Left CAN Joystick Y-axis Not In Neutral
CAN Joystick Information Error
No Communication From Drive Controller
Left Joystick X-axis Not In Neutral Left (ISO Mode Only)
Left Joystick Y-axis Not In Neutral
Right Joystick Y-axis Not In Neutral (H-Pattern Only)
Operating Mode Switch Short To Ground Or Battery
Right Front Wheel Unresponsive
Left Front Wheel Unresponsive
Right Rear Wheel Unresponsive
Left Rear Wheel Unresponsive
Left Swash Plate Not In Neutral
Right Swash Plate Not In Neutral
Left Joystick X-axis Out Of Range High
Left Joystick Y-axis Out Of Range High
Right Front Steering Sensor Out Of Range High
Left Front Steering Sensor Out Of Range High
Right Rear Steering Sensor Out Of Range High
Left Rear Steering Sensor Out Of Range High
Left Swash Plate Out Of Position
Right Swash Plate Out Of Position
Left Joystick X-axis Out Of Range Low
Left Joystick Y-axis Out Of Range Low
Right Front Steering Sensor Out Of Range Low
Left Front Steering Sensor Out Of Range Low
Right Rear Steering Sensor Out Of Range Low
Left Rear Steering Sensor Out Of Range Low
5.0 Volt Sensor Supply 1 Out Of Range Low
5 Volt Sensor Supply 2 Out Of Range Low
Left Swash Plate Sensor Out Of Range High
Left Swash Plate Sensor Out Of Range Low
Right Swash Plate Sensor Out Of Range High
Right Swash Plate Sensor Out Of Range Low
Left Forward Drive Solenoid Error On
Left Reverse Drive Solenoid Error On
Right Forward Drive Solenoid Error On
Right Reverse Drive Solenoid Error On
Right Front Extend Steering Solenoid Error On
Left Front Extend Steering Solenoid Error On
Right Rear Extend Steering Solenoid Error On
Left Rear Extend Steering Solenoid Error On
Pressure Control Steering Solenoid Error On
Backup Alarm Error On
Left Forward Drive Solenoid Error Off
Left Reverse Drive Solenoid Error Off
Right Forward Drive Solenoid Error Off
Right Reverse Drive Solenoid Error Off
Right Front Extend Steering Solenoid Error Off
Right Front Retract Steering Solenoid Error Off
Left Front Extend Steering Solenoid Error Off
Left Front Retract Steering Solenoid Error Off
Right Rear Extend Steering Solenoid Error Off
Right Rear Retract Steering Solenoid Error Off
Left Rear Extend Steering Solenoid Error Off
Left Rear Retract Steering Solenoid Error Off
Pressure Control Steering Solenoid Error Off
Backup Alarm Error Off
No Communication From Bobcat Controller
Angle Sensors Not Calibrated
Battery Voltage Out Of Range High
Interrupted Power
Battery Voltage Out Of Range Low
Drive Pump – Not Calibrated
Operating Mode Switch Flipped While Operating
Right Wheel Speed Uncommanded Motion
Left Wheel Speed Uncommanded Motion
No Communication From ACS Controller
Left Speed Sensor Out Of Range High
Right Speed Sensor Out Of Range High
Left Speed Sensor Out Of Range Low
Right Speed Sensor Out Of Range Low
Right Front Retract Steering Solenoid Error On
SSL Drive / Drive Plus Controller
Code
75-82
75-83
75-84
75-85
75-86
75-87
75-88
75-91
75-92
75-93
75-94
75-95
75-96
75-97
75-98
75-99
Description
Left Front Retract Steering Solenoid Error On
Right Rear Retract Steering Solenoid Error On
Left Rear Retract Steering Solenoid Error On
5.0 Volt Sensor Supply 1 Out Of Range High
Sensor Supply 2 Out Of Range High
Software Update Required
Switched Power Error On
Left Swash Plate Sensor - Reversed
Right Swash Plate Sensor - Reversed
Unresponsive Right Speed Sensor
Unresponsive Left Speed Sensor
Left Speed Sensor Reverse Direction
Right Speed Sensor Reverse Direction
Drive / Drive Plus Controller Programmed
Controller In Calibration Mode
Drive Plus Controller In Wheel Position Calibration Mode
Update June 2009
LOADER ALPHA‐NUMERIC CODES
Gateway Controller
Code
M0116
M0117
M0216
M0217
M0309
M0310
M0311
M0314
M0322
M0409
M0414
M0415
M0421
M0422
M0509
M0510
M0511
M0514
M0515
M0521
M0522
M0610
M0611
M0613
M0615
M0618
M0710
M0711
M0715
M0721
M0722
M0810
M0811
M0815
M0821
M0822
M0909
M0921
M0922
M1016
M1017
M1121
M1122
M1305
M1306
M1307
M1402
M1403
M1407
M1428
M1502
M1503
M1507
M1528
M1605
M1606
M1607
M1705
M1706
M1707
M1732
M1805
M1806
M1807
M1832
M2005
M2006
M2007
M2032
M2102
M2103
M2107
Description
Air Filter Not Connected
Air Filter Plugged
Hydraulic Implement Filter Not Connected
Hydraulic Implement Filter Plugged
Battery Voltage Low
Battery Voltage High
Battery Voltage Extremely High
Battery Voltage Extremely Low
Battery Voltage Out Of Range Low
Engine Oil Pressure Low
Engine Oil Pressure Extremely Low
Engine Oil Pressure In Shutdown
Engine Oil Pressure Out Of Range High
Engine Oil Pressure Out Of Range Low
Hydraulic Charge Pressure Low
Hydraulic Charge Pressure High
Hydraulic Charge Pressure Extremely High
Hydraulic Charge Pressure Extremely Low
Hydraulic Charge Pressure In Shutdown
Hydraulic Charge Pressure Out Of Range High
Hydraulic Charge Pressure Out Of Range Low
Engine Speed High
Engine Speed Extremely High
Engine Speed No Signal
Engine Speed In Shutdown
Engine Speed Out Of Range
Hydraulic Oil Temperature High
Hydraulic Oil Temperature Extremely High
Hydraulic Oil Temperature In Shutdown
Hydraulic Oil Temperature Out Of Range High
Hydraulic Oil Temperature Out Of Range Low
Engine Coolant Temperature High
Engine Coolant Temperature Extremely High
Engine Coolant Temperature In Shutdown
Engine Coolant Temperature Out Of Range High
Engine Coolant Temperature Out Of Range Low
Fuel Level Low
Fuel Level Out Of Range High
Fuel Level Out Of Range Low
Hydraulic Charge Filter Not Connected
Hydraulic Charge Filter Plugged
Seatbar Sensor Out Of Range High
Seatbar Sensor Out Of Range Low
Fuel Shutoff Hold Coil Short To Battery
Fuel Shutoff Hold Coil Short To Ground
Fuel Shutoff Hold Coil Open Circuit
Fuel Pull Output Error On
Fuel Pull Output Error Off
Fuel Pull Output Open Circuit
Fuel Pull Output Controller Failure
Traction Lock Pull Output Error On
Traction Lock Pull Output Error Off
Traction Lock Pull Output Open Circuit
Traction Lock Pull Output Controller Failure
Traction Lock Hold Solenoid Short To Battery
Traction Lock Hold Solenoid Short To Ground
Traction Lock Hold Solenoid Open Circuit
Hydraulic Lock Valve Solenoid Short To Battery
Hydraulic Lock Valve Solenoid Short To Ground
Hydraulic Lock Valve Solenoid Open Circuit
Hydraulic Lock Valve Solenoid Over Current
Lift Spool Lock Short To Battery
Lift Spool Lock Short To Ground
Lift Spool Lock Open Circuit
Lift Spool Lock Solenoid Over Current
Two Speed Solenoid Short To Battery
Two Speed Solenoid Short To Ground
Two Speed Solenoid Open Circuit
Two Speed Solenoid Over Current
Glow Plug Output Error On
Glow Plug Output Error Off
Glow Plug Output Open Circuit
Gateway Controller (Cont'd)
Code
M2128
M2202
M2203
M2207
M2228
M2302
M2303
M2307
M2402
M2403
M2407
M2502
M2503
M2507
M2602
M2603
M2607
M2805
M2806
M2807
M3028
M3128
M3204
M3304
M3323
M3404
M3505
M3506
M3507
M3532
M3648
M3705
M3706
M3707
M3732
M4109
M4110
M4404
M4621
M4622
M4721
M4722
M4802
M4803
M4807
M4902
M4903
M4907
M5002
M5003
M5007
M5028
M5102
M5103
M5107
M5128
M5202
M5221
M5222
M5305
M5306
M5405
M5406
M5407
M5432
M6402
M6403
M6407
M7002
M7003
M7007
M7028
Description
Glow Plug Output Controller Failure
Starter Output Error On
Starter Output Error Off
Starter Output Open Circuit
Starter Output Controller Failure
Starter Relay Error On
Starter Relay Error Off
Starter Relay Open Circuit
Fuel Pull Relay Error On
Fuel Pull Relay Error Off
Fuel Pull Output Open Circuit
Traction Lock Relay Error On
Traction Lock Pull Relay Error Off
Traction Lock Output Open Circuit
Glow Plug Relay Error On
Glow Plug Relay Error Off
Glow Plug Output Open Circuit
Auxiliary Interlock Output Short To Battery
Auxiliary Interlock Output Short To Ground
Auxiliary Interlock Output Open Circuit
Controller Memory Failure
Interrupted Power Failure
ACS In Error
Deluxe Panel No Communication
Gateway Controller Not Programmed
Deluxe Panel No Communication
Hydraulic Fan Solenoid Error On
Hydraulic Fan Solenoid Error Off
Hydraulic Fan Solenoid Open Circuit
Hydraulic Fan Solenoid Over Current
Multiple ACDs Present (Attachment Control Device)
Two Speed Secondary Error On
Two Speed Secondary Error Off
Two Speed Secondary Solenoid Open Circuit
Two Speed Secondary Over Current
Alternator Low Output
Alternator Voltage High
Auxiliary Controller No Communication
5 Volt Sensor Supply Out Of Range High
5 Volt Sensor Supply Out Of Range Low
8 Volt Sensor Supply Out Of Range High
8 Volt Sensor Supply Out Of Range Low
Front Light Relay Error On
Front Light Relay Error Off
Front Light Output Open Circuit
Rear Light Relay Error On
Rear Light Relay Error Off
Rear Light Output Open Circuit
Front Light Output Error On
Front Light Output Error Off
Front Light Output Open Circuit
Front Light Output Controller Failure
Rear Light Output Error On
Rear Light Output Error Off
Rear Light Output Open Circuit
Front Light Output Controller Failure
PTOL (Press To Operate Loader)Switch Error On
PTOL Switch Out Of Range High
PTOL Switch Out Of Range Low
PTOL Led Short To Battery
PTOL Led Short To Ground
Tilt Spool Lock Short To Battery
Tilt Spool Lock Short To Ground
Tilt Spool Lock Open Circuit
Tilt Spool Lock Over Current
Switched Power Relay Error On
Switched Power Relay Error Off
Switched Power Output Open Circuit
Switched Power Output Error On
Switched Power Output Error Off
Switched Power Output Open Circuit
Switched Power Output Controller Failure
Updated June 2009
LOADER ALPHA‐NUMERIC CODES
Gateway Controller (Cont'd)
Code
M7304
M7423
M7472
M7504
M7604
M7748
M7974
Description
Remote Control Receiver No Communication
Gateway Controller Not Programmed
Gateway Controller In Boot Code
Drive Controller No Communication
Left Display Panel No Communication
Key Switch Multiple
Door Open
Auxiliary Controller
Code
H1221
H1222
H1224
H1324
H2305
H2306
H2307
H2332
H2405
H2406
H2407
H2432
H2605
H2606
H2607
H2632
H2705
H2706
H2707
H2732
H2805
H2806
H2807
H2905
H2906
H2907
H2932
H3028
H3128
H3648
H3913
H3916
H3928
H3948
H4013
H4016
H4028
H4048
H4302
H4303
H4423
H4502
H4503
H4602
H4603
H4721
H4722
H7404
H7604
Description
Front Auxiliary Thumb Paddle Switch Out Of Range High
Front Auxiliary Thumb Paddle Switch Out Of Range Low
Front Auxiliary Thumb Paddle Switch Not In Neutral
Rear Auxiliary Thumb Paddle Switch Not In Neutral
Rear Base Solenoid Shorted to Battery
Rear Base Solenoid Short To Ground
Rear Base Solenoid Open Circuit
Rear Base Solenoid Over Current
Rear Rod Solenoid Short To Battery
Rear Rod Solenoid Short To Ground
Rear Rod Solenoid Open Circuit
Rear Rod Solenoid Over Current
Front Base Solenoid Short To Battery
Front Base Solenoid Short To Ground
Front Base Solenoid Open Circuit
Front Base Solenoid Over Current
Front Rod Solenoid Short To Battery
Front Rod Solenoid Short To Ground
Front Rod Solenoid Open Circuit
Front Rod Solenoid Over Current
Diverter Solenoid Short To Battery
Diverter Solenoid Short To Ground
Diverter Solenoid Open Circuit
High Flow Solenoid Short To Battery
High Flow Solenoid Short To Ground
High Flow Solenoid Open Circuit
High Flow Solenoid Over Current
Auxiliary Controller Memory Failure
Interrupted Power Failure
Multiple ACDs Present (Attachment Control Device)
Left CAN Joystick Grip No Communication
Left CAN Joystick Base No Communication
Left CAN Joystick Internal Failure
Left CAN Joystick Multiple
Right CAN Joystick Grip No Communication
Right CAN Joystick Base No Communication
Right CAN Joystick Internal Failure
Right CAN Joystick Multiple
Horn Relay Error On
Horn Relay Error Off
Auxiliary Controller Not Programmed
Right Blinker Error On
Right Blinker Error Off
Left Blinker Error On
Left Blinker Error Off
8 Volt Sensor Supply Out Of Range High
8 Volt Sensor Supply Out Of Range Low
Gateway Controller No Communication
Left Display Panel No Communication
ACD Controller
Code
A8002
A8003
A8102
A8103
A8202
A8203
A8302
A8303
A8402
A8403
A8502
A8503
A8602
A8603
A8702
A8703
Description
ACD/RACD Output "A" Error On
ACD/RACD Output "A" Error Off
ACD/RACD Output "B" Error On
ACD/RACD Output "B" Error Off
ACD/RACD Output "C" Error On
ACD/RACD Output "C" Error Off
ACD/RACD Output "D" Error On
ACD/RACD Output "D" Error Off
ACD/RACD Output "E" Error On
ACD/RACD Output "E" Error Off
ACD/RACD Output "F" Error On
ACD/RACD Output "F" Error Off
ACD/RACD Output "G" Error On
ACD/RACD Output "G" Error Off
ACD/RACD Output "H" Error On
ACD/RACD Output "H" Error Off
ACS Controller
Code
W3223
W3224
W3225
W3231
W3234
W3235
W3236
W3239
W3240
W3249
W3250
W3251
W3252
W3253
W3254
W3255
W3256
W3257
W3258
W3259
W3260
W3261
W3262
W3263
W3264
W3265
W3266
W3267
W3275
W3276
W3297
W3905
W4005
W4007
Description
ACS Controller Not Calibrated
ACS Controller Calibration Successful
ACS Controller Calibration Failure
ACS Tilt Actuator Fault
ACS Tilt Actuator Not In Neutral
ACS Tilt Handle/Pedal Not In Neutral
ACS Lift Actuator Fault
ACS Lift Actuator Not In Neutral (ACS Only)
ACS Lift Handle/Pedal Not In Neutral
ACS Lift Actuator Short To Ground (Error Off) (ACS Only)
ACS Tilt Actuator Short To Ground (Error Off)
ACS Lift Actuator Short To Battery (Error On) (ACS Only)
ACS Tilt Actuator Short To Battery (Error On)
ACS Lift Handle/Pedal Short To Ground
ACS Tilt Handle/Pedal Short To Ground
ACS Lift Handle/Pedal Short To Battery
ACS Tilt Handle/Pedal Short To Battery
ACS Lift Actuator Reduced Performance
ACS Tilt Actuator Reduced Performance
ACS Lift Actuator Wrong Direction (ACS Only)
ACS Tilt Actuator Wrong Direction
ACS Handle Lock Short To Ground
ACS Handle Lock Short To Battery
ACS Pedal Lock Short To Ground
ACS Pedal Lock Short To Battery
ACS Sensor Supply Voltage Out Of Range (ACS Only)
ACS Battery Voltage Out Of Range (ACS Only)
ACS Operating Mode Switch Flipped While Operating
Interrupted Un-switched Power
CAN Joystick Information Error
ACS Controller Programmed
Left CAN Joystick X-axis Not In Neutral
Right CAN Joystick X-axis Not In Neutral
Right CAN Joystick Y-axis Not In Neutral
Left Hand Panel Controller
Code
L0102
L0202
L0302
L0402
L7404
L7672
Description
Lights Button Error On
High Flow Button Error On
Auxiliary Button Error On
Information Button Error On
Gateway Controller No Communication
Left Hand Panel Programming Error
Updated June 2009
LOADER ALPHA‐NUMERIC CODES
SSL Drive / Drive Plus Controller
Code
D3905
D3907
D4007
D7501
D7509
D7513
D7514
D7515
D7516
D7517
D7518
D7523
D7524
D7525
D7526
D7527
D7528
D7533
D7534
D7535
D7536
D7537
D7538
D7539
D7540
D7541
D7542
D7543
D7544
D7545
D7546
D7547
D7548
D7549
D7550
D7551
D7552
D7553
D7554
D7555
D7556
D7557
D7558
D7559
D7560
D7561
D7562
D7563
D7564
D7565
D7566
D7567
D7568
D7569
D7570
D7571
D7572
D7573
D7574
D7575
D7577
D7578
D7579
D7580
D7581
D7582
D7583
D7584
D7585
D7586
D7587
D7588
Description
Left CAN Joystick X Axis Not in Neutral
Left CAN Joystick Y-axis Not In Neutral
Right CAN Joystick Y-axis Not In Neutral
CAN Joystick Information Error
Operating Mode Switch Short To Ground Or Battery
Right Front Wheel Unresponsive
Left Front Wheel Unresponsive
Right Rear Wheel Unresponsive
Left Rear Wheel Unresponsive
Left Swash Plate Not In Neutral
Right Swash Plate Not In Neutral
Right Front Steering Sensor Out Of Range High
Left Front Steering Sensor Out Of Range High
Right Rear Steering Sensor Out Of Range High
Left Rear Steering Sensor Out Of Range High
Left Swash Plate Out Of Position
Right Swash Plate Out Of Position
Right Front Steering Sensor Out Of Range Low
Left Front Steering Sensor Out Of Range Low
Right Rear Steering Sensor Out Of Range Low
Left Rear Steering Sensor Out Of Range Low
5.0 Volt Sensor Supply 1 Out Of Range Low
5 Volt Sensor Supply 2 Out Of Range Low
Left Swash Plate Sensor Out Of Range High
Left Swash Plate Sensor Out Of Range Low
Right Swash Plate Sensor Out Of Range High
Right Swash Plate Sensor Out Of Range Low
Left Forward Drive Solenoid Error On
Left Reverse Drive Solenoid Error On
Right Forward Drive Solenoid Error On
Right Reverse Drive Solenoid Error On
Right Front Extend Steering Solenoid Error On
Left Front Extend Steering Solenoid Error On
Right Rear Extend Steering Solenoid Error On
Left Rear Extend Steering Solenoid Error On
Pressure Control Steering Solenoid Error On
Backup Alarm Error On
Left Forward Drive Solenoid Error Off
Left Reverse Drive Solenoid Error Off
Right Forward Drive Solenoid Error Off
Right Reverse Drive Solenoid Error Off
Right Front Extend Steering Solenoid Error Off
Right Front Retract Steering Solenoid Error Off
Left Front Extend Steering Solenoid Error Off
Left Front Retract Steering Solenoid Error Off
Right Rear Extend Steering Solenoid Error Off
Right Rear Retract Steering Solenoid Error Off
Left Rear Extend Steering Solenoid Error Off
Left Rear Retract Steering Solenoid Error Off
Pressure Control Steering Solenoid Error Off
Backup Alarm Error Off
No Communication From Gateway Controller
Angle Sensors Not Calibrated
Battery Voltage Out Of Range High
Interrupted Power
Battery Voltage Out Of Range Low
Drive Pump – Not Calibrated
Operating Mode Switch Flipped While Operating
Right Wheel Speed Uncommanded Motion
Left Wheel Speed Uncommanded Motion
Left Speed Sensor Out Of Range High
Right Speed Sensor Out Of Range High
Left Speed Sensor Out Of Range Low
Right Speed Sensor Out Of Range Low
Right Front Retract Steering Solenoid Error On
Left Front Retract Steering Solenoid Error On
Right Rear Retract Steering Solenoid Error On
Left Rear Retract Steering Solenoid Error On
5.0 Volt Sensor Supply 1 Out Of Range High
Sensor Supply 2 Out Of Range High
Software Update Required
Switched Power Stuck On
SSL Drive / Drive Plus Controller (Cont'd)
Code
D7591
D7592
D7593
D7594
D7595
D7596
D7597
D7598
D7599
Description
Left Swash Plate Sensor - Reversed
Right Swash Plate Sensor - Reversed
Unresponsive Right Speed Sensor
Unresponsive Left Speed Sensor
Left Speed Sensor Reverse Direction
Right Speed Sensor Reverse Direction
Drive / Drive Plus Controller Programmed
Drive / Drive Plus Controller In Calibration Mode
Drive Plus Controller In Wheel Position Calibration Mode
Updated June 2009
EXCAVATOR XX‐XX CODES
Excavator Display Controller
Code
02-16
02-17
03-09
03-10
03-11
03-14
03-15
03-22
04-14
04-15
05-09
05-14
05-15
05-21
05-22
06-10
06-11
06-13
06-15
06-18
07-10
07-11
07-15
07-21
07-22
08-10
08-11
08-15
08-21
08-22
09-21
09-22
12-21
12-22
12-23
13-05
13-06
13-07
14-02
14-03
20-02
20-03
21-02
21-03
22-02
22-03
26-02
26-03
26-05
26-06
26-07
27-02
27-03
27-05
27-06
Description
Hydraulic/Hydrostatic Filter Not Connected
Hydraulic/Hydrostatic Filter Plugged
Battery Voltage Low
Battery Voltage High
Battery Voltage Extremely High
Battery Voltage Extremely Low
Battery Voltage In Shutdown
Battery Voltage Out Of Range Low
Engine Oil Pressure Extremely Low
Engine Oil Pressure Shutdown Level
Travel Pilot Pressure Low
Travel Pilot Pressure Extremely Low
Travel Pilot Pressure In Shutdown
Travel Pilot Pressure Out Of Range High
Travel Pilot Pressure Out Of Range Low
Engine Speed High
Engine Speed Extremely High
Engine Speed No Signal
Engine Speed In Shutdown
Engine Speed Out Of Range High
Hydraulic Oil Temperature High
Hydraulic Oil Temperature Extremely High
Hydraulic Oil Temperature In Shutdown
Hydraulic Oil Temperature Out Of Range High
Hydraulic Oil Temperature Out Of Range Low
Engine Coolant Temperature High
Engine Coolant Temperature Extremely High
Engine Coolant Temperature In Shutdown
Engine Coolant Temperature Out Of Range High
Engine Coolant Temperature Out Of Range Low
Fuel Level Out Of Range High
Fuel Level Out Of Range Low
Auxiliary PWM Switch Out Of Range High
Auxiliary PWM Switch Out Of Range Low
Auxiliary PWM Switch Not In Neutral
Fuel Shutoff Hold Solenoid Short To Battery
Fuel Shutoff Hold Solenoid Short To Ground
Fuel Shutoff Hold Solenoid Open Circuit
Fuel Shutoff Pull Solenoid Error On
Fuel Shutoff Pull Solenoid Error Off
Two Speed Error On
Two Speed Error Off
Glow Plug Error On
Glow Plug Error Off
Starter Error On
Starter Error Off
Front Base Solenoid Error On
Front Base Solenoid Error Off
Front Base PWM Short to Battery
Front Base PWM Short to Ground
Front Base PWM Open Circuit
Front Rod Solenoid Error On
Front Rod Solenoid Error Off
Front Rod PWM Short to Battery
Front Rod PWM Short to Ground
Excavator Display Controller
Code
20-03
21-02
21-03
22-02
22-03
26-02
26-03
26-05
26-06
26-07
27-02
27-03
27-05
27-06
27-07
28-02
28-03
31-28
33-23
35-05
35-06
62-04
63-05
63-06
64-05
64-06
64-07
65-05
65-06
65-07
66-05
66-06
66-07
Description
Two Speed Error Off
Glow Plug Error On
Glow Plug Error Off
Starter Error On
Starter Error Off
Front Base Solenoid Error On
Front Base Solenoid Error Off
Front Base PWM Short to Battery
Front Base PWM Short to Ground
Front Base PWM Open Circuit
Front Rod Solenoid Error On
Front Rod Solenoid Error Off
Front Rod PWM Short to Battery
Front Rod PWM Short to Ground
Front Rod PWM Open Circuit
Diverter Solenoid Error On
Diverter Solenoid Error Off
Interrupted Power Failure
Main Controller Not Programmed
Hydraulic Fan Short To Battery
Hydraulic Fan Short To Ground
Load Moment Monitoring In Error
Console Switch Short To Battery
Console Switch Short To Ground
Switched Power Relay Short To Battery
Switched Power Relay Short To Ground
Switched Power Relay Open Circuit
Workgroup Lockout Solenoid Short To Battery
Workgroup Lockout Solenoid Short To Ground
Workgroup Lockout Solenoid Open Circuit
Travel Pilot Pressure Short To Battery
Travel Pilot Pressure Short To Ground
Travel Pilot Pressure Open Circuit
Updated June 2009
EXCAVATOR ALPHA‐NUMERIC CODES
Excavator Display Controller
Code
C0216
C0217
C0309
C0310
C0311
C0314
C0315
C0322
C0414
C0415
C0610
C0611
C0613
C0615
C0618
C0710
C0711
C0715
C0721
C0722
C0810
C0811
C0815
C0821
C0822
C0921
C0922
C1221
C1222
C1223
C1305
C1306
C1307
C1402
C1403
C2005
C2006
C2102
C2103
C2202
C2203
C2305
C2306
C2307
C2405
C2406
C2407
C2505
C2506
C2507
C2605
C2606
C2607
C2705
C2706
C2707
C2802
Description
Hydraulic/Hydrostatic Filter Not Connected
Hydraulic/Hydrostatic Filter Plugged
Battery Voltage Low
Battery Voltage High
Battery Voltage Extremely High
Battery Voltage Extremely Low
Battery Voltage In Shutdown
Battery Voltage Out Of Range Low
Engine Oil Pressure Extremely Low
Engine Oil Pressure In Shutdown
Engine Speed High
Engine Speed Extremely High
Engine Speed No Signal
Engine Speed In Shutdown
Engine Speed Out Of Range High
Hydraulic Oil Temperature High
Hydraulic Oil Temperature Extremely High
Hydraulic Oil Temperature In Shutdown
Hydraulic Oil Temperature Out Of Range High
Hydraulic Oil Temperature Out Of Range Low
Engine Coolant Temperature High
Engine Coolant Temperature Extremely High
Engine Coolant Temperature In Shutdown
Engine Coolant Temperature Out Of Range High
Engine Coolant Temperature Out Of Range Low
Fuel Level Out Of Range High
Fuel Level Out Of Range Low
Auxiliary PWM Switch Out Of Range High
Auxiliary PWM Switch Out Of Range Low
Auxiliary PWM Switch Not In Neutral
Fuel Shutoff Hold Solenoid Short To Battery
Fuel Shutoff Hold Solenoid Short To Ground
Fuel Shutoff Hold Solenoid Open Circuit
Fuel Shutoff Pull Solenoid Error On
Fuel Shutoff Pull Solenoid Error Off
Two Speed Error On
Two Speed Error Off
Glow Plug Error On
Glow Plug Error Off
Starter Error On
Starter Error Off
Offset Base Solenoid Short To Battery
Offset Base Solenoid Short to Ground
Offset Base Solenoid Open Circuit
Offset Rod Solenoid Short To Battery
Offset Rod Solenoid Short to Ground
Offset Rod Solenoid Open Circuit
Offset Return Short To Battery
Offset Return Short To Ground
Offset Return Open Circuit
Auxiliary Base Solenoid Short to Battery
Auxiliary Base Solenoid Short to Ground
Auxiliary Base Solenoid Open Circuit
Auxiliary Rod Solenoid Short to Battery
Auxiliary Rod Solenoid Short to Ground
Auxiliary Rod Solenoid Open Circuit
Hydraulic Exchange Error On
Excavator Display Controller (Cont'd)
Code
C2803
C3028
C3128
C3323
C3397
C4021
C4022
C4023
C4105
C4106
C4107
C4205
C4206
C4207
C4321
C4322
C4516
C6021
C6022
C6023
C6204
C6305
C6306
C6405
C6406
C6407
C6505
C6506
C6507
Description
Hydraulic Exchange Error Off
Controller Memory Failure
Interrupted Power Failure
Main Controller Not Programmed
Main Controller Programmed
Angle Blade Control Out Of Range High
Angle Blade Control Out Of Range Low
Angle Blade Control Not In Neutral
Angle Blade Base Solenoid Short to Battery
Angle Blade Base Solenoid Short to Ground
Angle Blade Base Solenoid Open Circuit
Angle Blade Rod Solenoid Short to Battery
Angle Blade Rod Solenoid Short to Ground
Angle Blade Rod Solenoid Open Circuit
Load Sense Pressure Out Of Range High
Load Sense Pressure Out Of Range Low
Throttle Controller No Communication
Offset Control Out Of Range High
Offset Control Out Of Range Low
Offset Control Not In Neutral
Load Moment Monitoring In Error
Console Switch Short To Battery
Console Switch Short To Ground
Switched Power Relay Short To Battery
Switched Power Relay Short To Ground
Switched Power Relay Open Circuit
Workgroup Lockout Solenoid Short To Battery
Workgroup Lockout Solenoid Short To Ground
Workgroup Lockout Solenoid Open Circuit
Code
E0105
E0106
E0107
E0123
E0321
E0322
E0421
E0422
E0521
E0522
Description
Throttle Actuator Short To Battery
Throttle Actuator Short To Ground
Throttle Actuator Open Circuit
Throttle Controller Not Calibrated
5 Volt Sensor Supply Out Of Range High
5 Volt Sensor Supply Out Of Range Low
Engine Speed Control Dial Out Of Range High
Engine Speed Control Dial Out Of Range Low
Throttle Actuator Feedback Out Of Range High
Throttle Actuator Feedback Out Of Range Low
Engine Controller
Updated June 2009
E60/E80 E‐ECU CONTROLLER CODES
E60/E80 E-ECU Controller
Code
P0117
P0118
P0119
P0122
P0123
P0124
P0217
P0340
P0562
P0563
P0605
P0634
P0642
P0643
P0668
P0669
P1202
P1203
P1211
P1212
P1213
P1222
P1223
P1224
P1232
P1233
P1234
P1242
P1243
P1244
P1402
P1403
P1412
P1413
P1422
P1423
P1432
P1433
P1605
P1606
P1644
P1664
Description
Engine Coolant Temperature Sensor Out Of Range Low
Engine Coolant Temperature Sensor Out Of Range High
Engine Coolant Temperature Sensor Intermittent Connection
Accelerator Sensor Out Of Range Low
Accelerator Sensor Out Of Range High
Accelerator Sensor Intermittent Connection
Engine Coolant Temperature High
Engine Speed Sensor No Signal
Battery Voltage Low
Battery Voltage High
E-ECU Internal FlashROM Checksum Error A (Main Software)
E-ECU Temperature Sensor High
5 Volt Sensor Supply Out Of Range Low
5 Volt Sensor Supply Out Of Range High
E-ECU Temperature Sensor Out Of Range Low
E-ECU Temperature Sensor Out Of Range High
Rack Position Sensor Out Of Range Low
Rack Position Sensor Out of Range High
Rack Actuator Solenoid Stuck
Rack Actuator Solenoid Undercurrent
Rack Actuator Solenoid Overcurrent
Rack Actuator Relay Error On
Rack Actuator Relay Error Off
Rack Actuator Relay Intermittent Connection
Preheat relay Error On
Preheat relay Error Off
Preheat Relay Intermittent Connection
CSD Solenoid Valve Error On
CSD Solenoid Valve Error Off
CSD Solenoid Valve Intermittent Connection
EGR Valve Phase A Error On
EGR Valve Phase A Error Off
EGR Valve Phase B Error On
EGR Valve Phase B Error Off
EGR Valve Phase C Error On
EGR Valve Phase C Error Off
EGR Valve Phase D Error On
EGR Valve Phase D Error Off
E-ECU Internal FlashROM Checksum Error B (Main Software)
E-ECU Internal FlashROM Checksum Error C (Main Software)
5 Volt Sensor Supply Intermittent Connection
E-ECU Temperature Sensor Intermittent Connection
TOOLCAT XX‐XX CODES
Toolcat Display Controller
Code
02-16
02-17
03-09
03-10
03-11
03-14
03-15
03-22
04-14
04-15
06-10
06-11
06-13
06-15
06-18
07-10
07-11
07-15
07-21
07-22
08-10
08-11
08-15
08-21
08-22
09-09
09-21
09-22
12-21
12-22
12-23
13-05
13-06
13-07
14-02
14-03
18-05
18-06
18-07
20-02
20-03
21-02
21-03
22-02
22-03
26-02
26-03
27-02
27-03
28-02
28-03
29-02
29-03
30-28
31-28
33-23
35-05
35-06
36-48
63-05
63-06
64-05
64-06
64-07
65-05
65-06
65-07
67-05
67-06
69-05
69-06
69-07
Description
Hydraulic Charge Filter Not Connected
Hydraulic Charge Filter Plugged
Battery Voltage Low
Battery Voltage High
Battery Voltage Extremely High
Battery Voltage Extremely Low
Battery Voltage In Shutdown
Battery Voltage Out Of Range Low
Engine Oil Pressure Extremely Low
Engine Oil Pressure Shutdown Level
Engine Speed High
Engine Speed Extremely High
Engine Speed No Signal
Engine Speed In Shutdown
Engine Speed Out Of Range High
Hydraulic Oil Temperature High
Hydraulic Oil Temperature Extremely High
Hydraulic Oil Temperature In Shutdown
Hydraulic Oil Temperature Out Of Range High
Hydraulic Oil Temperature Out Of Range Low
Engine Coolant Temperature High
Engine Coolant Temperature Extremely High
Engine Coolant Temperature In Shutdown
Engine Coolant Temperature Out Of Range High
Engine Coolant Temperature Out Of Range Low
Fuel Level Low
Fuel Level Out Of Range High
Fuel Level Out Of Range Low
Auxiliary PWM Switch Out Of Range High
Auxiliary PWM Switch Out Of Range Low
Auxiliary PWM Switch Not In Neutral
Fuel Shutoff Hold Solenoid Short To Battery
Fuel Shutoff Hold Solenoid Short To Ground
Fuel Shutoff Hold Solenoid Open Circuit
Fuel Shutoff Pull Solenoid Error On
Fuel Shutoff Pull Solenoid Error Off
Spool Lock Short To Battery
Spool Lock Short To Ground
Spool Lock Open Circuit
Two Speed Error On
Two Speed Error Off
Glow Plug Error On
Glow Plug Error Off
Starter Error On
Starter Error Off
Front Base Output Error On
Front Base Output Error Off
Front Rod Solenoid Error On
Front Rod Solenoid Error Off
Diverter Solenoid Error On
Diverter Solenoid Error Off
High Flow Solenoid Error On
High Flow Solenoid Error Off
Controller Memory Failure
Interrupted Power Failure
Main Controller Not Programmed
Two Speed Fan Short To Battery
Two Speed Fan Short To Ground
ACD Multiple Controllers Present
TICS Sensor Short To Battery
TICS Switch Short To Ground
Switched Power Relay Short To Battery
Switched Power Relay Short To Ground
Switched Power Relay Open Circuit
Workgroup Lockout Solenoid Short To Battery
Workgroup Lockout Solenoid Short To Ground
Workgroup Lockout Solenoid Open Circuit
Bobtach Short To Battery
Bobtach Short To Ground
Operator Presence Relay Short To Battery
Operator Presence Relay Short To Ground
Operator Presence Relay Open Circuit
Toolcat Drive Controller
Code
50-01
50-02
50-03
50-04
50-05
50-06
50-07
50-08
50-09
50-10
50-11
50-12
50-13
50-14
50-15
50-19
50-20
50-24
50-25
50-26
50-27
50-28
50-29
50-30
50-31
50-32
50-33
50-34
50-35
50-36
50-37
50-38
50-39
50-40
50-41
50-42
50-43
50-44
50-45
50-46
50-47
50-48
50-49
50-50
50-51
50-52
50-53
50-54
50-55
50-56
50-57
50-59
50-60
50-61
50-63
50-65
50-66
50-67
50-68
50-69
50-70
50-72
50-74
50-75
50-76
50-77
50-78
50-80
50-81
50-82
50-99
Description
Drive Pedal Out Of Range High
Drive Pedal Out Of Range Low
Travel Pedal Not Calibrated
Brake Pedal Out Of Range High
Brake Pedal Out Of Range Low
Brake Pedal Not Calibrated
Travel Direction Control Lever No Signal
Travel Direction Control Lever Multiple Inputs
Front Wheel Speed Sensor Out Of Range High
Front Wheel Speed Sensor Out Of Range Low
Rear Wheel Speed Sensor Out Of Range High
Rear Wheel Speed Sensor Out Of Range Low
Front Wheel Speed Sensor No Signal
Rear Wheel Speed Sensor No Signal
Dual Wheel Speed Sensor Fault
Swash Plate Sensor Out Of Range High
Swash Plate Sensor Out Of Range Low
Battery Voltage Over Voltage
Battery Voltage Under Voltage
Interrupted Power
5.0 Volt Sensor Supply 1 Out Of Range High
5.0 Volt Sensor Supply 1 Out Of Range Low
5.0 Volt Sensor Supply 2 Out Of Range High
5.0 Volt Sensor Supply 2 Out Of Range Low
Front Drive PWM Solenoid Error On
Forward Drive Coil Short To Battery
Front Drive PWM Solenoid No Signal
Front Drive PWM Solenoid Not Calibrated
Front Drive Forward Solenoid Error On
Front Drive Forward Solenoid Error Off
Front Drive Reverse Solenoid Error On
Front Drive Reverse Solenoid Error Off
Rear Drive PWM Solenoid Error On
Reverse Drive Coil Short To Battery
Rear Drive PWM Solenoid No Signal
Rear Drive PWM Solenoid Not Calibrated
Rear Drive Forward Solenoid Error On
Rear Drive Forward Solenoid Error Off
Rear Drive Reverse Solenoid Error On
Rear Drive Reverse Solenoid Error Off
Two Speed Error Off
Two Speed Error On
Brake Solenoid Error On
Brake Solenoid Error Off
Brake Solenoid No Signal
Brake Lights Short To Battery
Brake Lights Short To Ground
Differential Lock Error On
Differential Lock Error Off
CAN Communications Fault
Drive Controller Not Calibrated
Front Wheel Speed Sensor Missing Pulses
Remote Hydraulics Short To Battery
Remote Hydraulics Short To Ground
Front Angle Sensor Calibration Error
Auxiliary Base Coil Short To Ground or Open Circuit
Rear Angle Sensor Calibration Error
Front Drive Forward No Signal
Front Drive Reverse No Signal
Rear Drive Forward No Signal
Rear Drive Reverse No Signal
Fan Coil Short To Ground
Throttle Sensor Channel A Out Of Range Low
Throttle Sensor Channel B Out Of Range High
Throttle Sensor Channel B Out Of Range Low
Auxiliary Diverter Error On
Auxiliary Diverter Error Off
PTO Speed Sensor Out Of Range High
PTO Speed Sensor Out Of Range Low
PTO Speed Sensor Open Circuit
In Calibration Mode
Updated June 2009
VersaHANDLER XX‐XX CODES
VersaHANDLER Display Controller
Code
02-16
02-17
03-09
03-10
03-11
03-14
03-15
03-22
04-14
04-15
06-10
06-11
06-13
06-15
06-18
07-10
07-11
07-15
07-21
07-22
08-10
08-11
08-15
08-21
08-22
09-21
09-22
13-05
13-06
13-07
14-02
14-03
21-02
21-03
22-02
22-03
30-28
31-28
33-23
36-48
63-05
63-06
64-05
64-06
64-07
65-05
65-06
65-07
70-28
77-48
Description
Hydraulic Charge Filter Not Connected
Hydraulic Charge Filter Plugged
Battery Voltage Low
Battery Voltage High
Battery Voltage Extremely High
Battery Voltage Extremely Low
Battery Voltage in Shutdown
Battery Voltage Out of Range Low
Engine Oil Pressure Extremely Low
Engine Oil Pressure in Shutdown
Engine Speed High
Engine Speed Extremely High
Engine Speed No Signal
Engine Speed In Shutdown
Engine Speed Out of Range
Hydraulic Oil Temperature High
Hydraulic Oil Temperature Extremely High
Hydraulic Oil Temperature In Shutdown
Hydraulic Oil Temperature Out Of Range High
Hydraulic Oil Temperature Out Of Range Low
Engine Coolant Temperature High
Engine Coolant Temperature Extremely High
Engine Coolant Temperature In Shutdown
Engine Coolant Temperature Out Of Range High
Engine Coolant Temperature Out of Range Low
Fuel Level Out Of Range High
Fuel Level Out Of Range Low
Fuel Shutoff Hold Solenoid Short To Battery
Fuel Shutoff Hold Solenoid Short To Ground
Fuel Shutoff Hold Solenoid Open Circuit
Fuel Shutoff Pull Solenoid Error On
Fuel Shutoff Pull Solenoid Error Off
Glow Plug Error On
Glow Plug Error Off
Starter Error On
Starter Error Off
Controller Memory Failure
Interrupted Power
Constant Data Not Calibrated
ACD (Attachment Control Device) Multiple Controllers Present
Operator Presence Sensor Short To Battery
Operator Presence Sensor Short to Ground
Switched Power Relay Short To Battery
Switched Power Relay Short To Ground
Switched Power Relay Open Circuit
Joystick Lockout Short To Battery
Joystick Lockout Short To Ground
Joystick Lockout Open Circuit
Brake Pressure Failure
Key Switch Multiple
VersaHANDLER Drive Controller
Code
50-02
50-03
50-04
50-05
50-06
50-07
50-14
50-15
50-16
50-20
50-21
50-23
50-24
50-25
50-26
50-28
50-29
50-30
50-31
50-33
50-34
50-36
50-37
50-42
50-43
50-45
50-46
50-48
50-49
50-50
50-51
50-54
50-55
50-56
50-57
50-58
50-60
50-61
50-63
50-64
50-66
50-67
50-69
50-70
50-72
50-73
50-78
50-79
50-80
50-81
50-82
Description
Extend / Retract Control Out of Range High
Extend/Retract Control Out of Range Low
Extend/Retract Control Not In Neutral
Auxiliary Control Out of Range High
Auxiliary Control Out of Range Low
Auxiliary Control Not In Neutral
Inching Control Out of Range High
Inching Control Out of Range Low
Inching Control Not Calibrated
Boom Pressure Out Of Range High
Boom Pressure Out Of Range Low
Drive Controller Not Programmed
Stability Valve Error On
Stability Valve Error Off
Interrupted Power
FNR No Inputs Active
FNR More than One Input Active
Rear Light Relay Error On
Rear Light Relay Error Off
Passive Brake Valve Error On
Passive Brake Valve Error Off
Brake Light Relay Error On
Brake Light Relay Error Off
Secondary Auxiliary Hydraulic Valve Error On
Secondary Auxiliary Hydraulic Valve Error Off
Extend/Retract Base Error On
Extend/Retract Base Error Off
5 Volt Sensor Supply 1 Out Of Range Low
5 Volt Sensor Supply 1 Out Of Range High
5 Volt Sensor Supply 2 Out of Range Low
5 Volt Sensor Supply 2 Out of Range High
Switched Battery Over Voltage
Switched Battery Under Voltage
CAN Communication Fault
Drive Controller Not Calibrated
CAN RPM Message Stale
Drive Pump Forward Error On
Drive Pump Forward Error Off
Drive Pump Reverse Error On
Drive Pump Reverse Error Off
Extend/Retract Rod Error On
Extend/Retract Rod Error Off
Auxiliary Hydraulics Base Error On
Auxiliary Hydraulics Base Error Off
Auxiliary Hydraulics Rod Error On
Auxiliary Hydraulics Rod Error Off
Boom Float Relay Error On
Boom Float Relay Error Off
Two Speed Relay Error On
Two Speed Relay Error Off
EEPROM Error
Update June 2009